Re: SPIM08HP 3.7V 16AH Battery which can handle 200 amp pluses Battery Hookup
Your right about this but finding the right one is the issue and most of them are not designed right either they over charge over time or they do not charge enough and leave battery at 70% and not at 95 to 98% which would be better
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
But I going to turn this in to two 20 volt battery packs instead of the setup that it is right now
For the battery operated air compressor that I had bought several months ago
One note they have sold out of them several times before
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
But I going to turn this in to two 20 volt battery packs instead of the setup that it is right now
For the battery operated air compressor that I had bought several months ago
One note they have sold out of them several times before
One note I decided not to test on the new battery tester because of the data code on the battery pack I decided to use the other battery testing machine instead for a more accurate testing results but once I get the batteries matching close to each other then I will put it on the other battery tester and run it at a 8 amp load and see what the results look like
I have tested a few of these for this pack and they seem to have around 90% life left in them for batteries that have a date code of 2015 on them
They are suppose to test at 8 amp hours but are testing at around 7.0** to 7.1**something amp hours
The discharge curve looks good until it reaches the 3.45 volts and drops faster than I would expected it to be it should drop at lower voltage maybe closer to 3.0 would be a lot better
This discharge curve looks pretty decent for it age still a lot of life in it I tested one for 5 minutes @8 amp load on the testing machine and the results were pretty good at 8 amp load
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
One note I decided not to test on the new battery tester because of the data code on the battery pack I decided to use the other battery testing machine instead for a more accurate testing results but once I get the batteries matching close to each other then I will put it on the other battery tester and run it at a 8 amp load and see what the results look like
I have tested a few of these for this pack and they seem to have around 90% life left in them for batteries that have a date code of 2015 on them
They are suppose to test at 8 amp hours but are testing at around 7.0** to 7.1**something amp hours
The discharge curve looks good until it reaches the 3.45 volts and drops faster than I would expected it to be it should drop at lower voltage maybe closer to 3.0 would be a lot better
This discharge curve looks pretty decent for it age still a lot of life in it I tested one for 5 minutes @8 amp load on the testing machine and the results were pretty good at 8 amp load
Testing has been suspend from 1-2-22 for the rest of the week because of work and having to work 13 days with no days off because of some special project that they want to do
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
Re: SPIM08HP 3.7V 16AH Battery which can handle 200 amp pluses Battery Hookup
Well I have tested about half of them and the results are as follows
6800 to 7*** something these batteries are not quite as good as the signal double battery pack cells are but I can still use them but a little disappointed that they are as good and have found that some of the battery cells have a self discharge issue which is going to add to how I group these batteries to make a battery pack
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
Re: SPIM08HP 3.7V 16AH Battery which can handle 200 amp pluses Battery Hookup
Yeah I know all I can do is group them the best that I can and the ones that have a bad self discharge rate maybe use a couple of them for solar lighting around my shed and maybe in the font yard I have a few solar panels that I could use for this project
9 PC LCD Monitor
6 LCD Flat Screen TV
30 Desk Top Switching Power Supply
10 Battery Charger Switching Power Supply for Power Tool
6 18v Lithium Battery Power Boards for Tool Battery Packs
1 XBox 360 Switching Power Supply and M Board
25 Servo Drives 220/460 3 Phase
6 De-soldering Station Switching Power Supply 1 Power Supply
1 Dell Mother Board
15 Computer Power Supply
1 HP Printer Supply & Control Board * lighting finished it *
These two repairs where found with a ESR meter...> Temp at 50*F then at 90*F the ESR reading more than 10%
1 Over Head Crane Current Sensing Board ( VFD Failure Five Years Later )
2 Hem Saw Computer Stack Board
All of these had CAPs POOF
All of the mosfet that are taken out by bad caps
Comment